Ladies and gentlemen, good morning, and welcome to the Second Quarter 2019 Earnings Release Conference Call for FMC Corporation. Phone lines will be placed on a listen only mode throughout the conference. After the speakers' presentation, there will be a question and answer period. As a reminder, this conference is being recorded. I will now turn the conference over to Mr.
Michael Worley, Director of Investor Relations for FMC Corporation. Mr. Worley, you may begin.
Thank you, and good morning, everyone. Welcome to FMC Corporation's 2nd quarter earnings call. Joining me today are Pierre Brondeau, Chief Executive Officer and Chairman Mark Douglas, President and Chief Operating Officer and Pierre will review FMC's 2nd quarter performance and provide the outlook for the rest of 2019. Andrew will provide an overview of select financial results. Mark will then address the long term sustainable growth for Rynaxper and SaaS per insect controls.
We will then address your questions. The slide presentation that accompanies our results along with our earnings release and 2019 outlook are available on our website, and the prepared remarks from today's discussion will be made available after the call. Finally, let me remind you that today's presentation and discussion will include forward looking statements that are subject to various risks and uncertainties concerning specific factors, including but not limited to those factors identified in our press release and in our filings with the SEC. Information presented represents our best judgment based on today's information. Actual results may vary based upon these risks and uncertainties.
Today's discussion and the supporting materials will include references to adjusted EPS, adjusted EBITDA, adjusted cash from operations and free cash flow, all of which are non GAAP financial measures. Please note that earnings shall mean adjusted earnings and EBITDA shall mean adjusted EBITDA for all income state references. A reconciliation and definition of these terms as well as other non GAAP financial terms to which we may refer during today's call are provided on our website. With that, I'll now turn the call over to Pierre.
Thank you, Michael, and good morning, everyone. As you saw in our earnings release, FMC continued to outperform the market as we have for the past 7 quarters. We delivered results in line with the forecast and adjusted to specific global conditions in the quarter. Turning to Slide 3, FMC reported $1,200,000,000 in 2nd quarter revenue, which reflects a year over year increase of 4.5% on a reported basis and 9% organic growth excluding FX headwinds. This increase was mostly driven by strength in Brazil, India and the EMEA.
Adjusted company EBITDA was $330,000,000 an increase of 6% compared to recast financials from last year and $3,000,000 above the midpoint of the guidance. Company EBITDA margins were up 20 percent, up year over year despite $64,000,000 in combined headwinds from raw material costs and foreign currencies. Adjusted EPS was $1.66 in the quarter, an increase of 11% versus recast Q2 2018 and $0.01 above the midpoint of our guidance. The strong year over year EPS growth was driven by price increase, higher volume and the lower share count. Moving now to 2nd quarter revenue on Slide 4.
Q2 revenue grew 4.5% versus prior year with volume contributing 5% growth and price mix another 3% growth. This was offset partially by a 4% headwind from FX. Although Q2 is a seasonally smaller quarter of the year in Latin America, sales in that region grew 29% year over year or 34% organically continuing the trend from Q1. Drivers include strong revenue growth in Brazil across the portfolio with high demand for applications on carton and sugarcane and price increases that more than offset the impact of FX on both revenue and earnings. Following such a strong first half in Latin America, it is important to note that we continue to monitor channel inventory levels of FMC products very closely in Brazil.
They are at an all time low for this point in the season. In EMEA, improved market conditions in Russia and Ukraine, good demand in Southwest Europe and new country registrations for cyazapyr in Sext Control drove year over year revenue growth of 4%, organic growth was 10%. In Asia, revenue was down 2% overall, but increased 4% organically year over year. We were especially pleased with the strong performance in India, where our sales grew over 20% driven by growth in herbicides for sugarcane and the benefits of our new commercial organization structure, which we put in place about a year ago. In North America, revenue was down 2% year over year as the well understood weather issues in the quarter caused a reduction in demand from the row crop customers.
This low demand was offset in part by strong sales of ronaxypyr insect control, especially in niche crops in California and our new fungicide Lucento. Turning to Slide 5, 2nd quarter EBITDA was $338,000,000 price increases in all regions and strong volume demand everywhere but North America combined to more than offset the headwinds from raw material cost and FX leading to 6% growth versus recast results from Q2 2018. Moving to our 2019 outlook on Slide 6. We are maintaining our guidance for 2019 revenue and EBITDA. We expect full year 2019 revenue to grow 6% at the midpoint or 9% organic growth, excluding a forecasted 3% FX headwind.
We expect total company EBITDA to grow 8%. We are increasing our 2019 EPS guidance to a range of $5.68 to 5.8 $8 which represents a gain of 10% at the midpoint over recast 2018. Our EPS guidance now reflects the $200,000,000 of buybacks completed in the first half of twenty nineteen as well as an additional $200,000,000 of buyback anticipated in the second half. We continue to plan to make $400,000,000 to $500,000,000 in total share repurchase in 2019, but our EPS guidance reflects the lower end of this range. For the Q3, we expect revenue to be in the range of $960,000,000 to $990,000,000 which represents year over year growth of 6% at the midpoint.
We are also forecasting EBITDA of $190,000,000 to $210,000,000 in Q3, which would be an increase of 7% year over year at the midpoint. As expected, the impact from FX will be more muted in the second half of the year. We expect 3rd quarter EPS to be in the range of $0.75 to $0.85 up 13% at the midpoint versus recast results from Q3, twenty nineteen. The 3rd quarter is a seasonally smallest quarter for FMC, which is in line with the quarterly pattern from 2018 as Q3 is not a high season in any other regions. The healthy growth with forecast is in line with the full year growth expectation and the Q3 guidance is essentially in line with the prior year period as a percent of annual sales, annual EBITDA and annual EPS.
Guidance for Q4 implies a very strong quarter with sales growth of 7%, EBITDA growth of 17% and EPS growth of 10%, all at the midpoint of the ranges versus Wecast Q4 2018 results. Q4 performance will be driven by Latin America. In Brazil, similar to last year, we have already received nearly 70% of the orders needed to deliver our 2nd half forecast. This is giving us a very strong confidence in our ability to deliver our financial targets for the second half. However, we are carefully monitoring the North America market and channel inventories.
For 2019, we now expect the overall global crop protection market will be flat on a U. S. Dollar basis, down slightly from our previous outlook. We expect Latin America to grow faster in the high single digit and North America to be weaker down mid single digits. These adjustments in market forecast does not change our overall outlook for FMC's financial outperformance related to the market.
Turning now to a full year EBITDA bridge and revenue drivers on Slide 7. Our full year cost headwind is higher than prior forecast, mainly due to increased tariffs in the U. S. And a delayed reopening of a key tolling partner in China. However, strong pricing is now expected to offset over 70% of the $220,000,000 in combined headwinds from cost and FX.
Moving to Slide 8, we provide the key drivers for EBITDA and revenue growth in Q3 and Q4. Volume growth and price increases are expected to be consistent driver of the revenue and earnings performance. I will now turn the call over to Andrew.
Thanks, Bir. Let me start this morning with a few specific income statement items. Interest expense for the quarter was $4,000,000 higher than implied by our prior full year guidance due to higher interest rates on foreign borrowings and higher than anticipated commercial paper balances. Interest expense for the full year is now expected to be in the range of $144,000,000 to $148,000,000 The adjusted effective tax rate for the quarter was 15%. We are maintaining our full year tax rate guidance of 14% to 16%.
Weighted average diluted shares outstanding for the Q2 was 132,300,000, down nearly 4,000,000 shares versus the prior year period, reflecting the benefit of the $400,000,000 in share repurchases we've made over the past 3 quarters. Moving on to the balance sheet and cash flow. Gross debt as of June 30 was $3,200,000,000 up roughly $100,000,000 from the end of March. Gross debt to trailing 12 month EBITDA at quarter end was 2.8 times. This is above our targeted leverage of 2.5 times due to the seasonality of our cash flow and the timing of share repurchases.
We continue to expect to see leverage drop to 2.5 times or lower for the full year. Turning to Slide 9. Adjusted cash from operations was negative $174,000,000 in the first half of twenty nineteen, below the prior year period. Non recurring impacts that benefited working capital in the prior year period, as discussed in our last earnings call, remained the largest contributor to the year on year change. Additionally, cash from operations in the second quarter was also impacted by credit term accommodations made to certain North American customers in light of extreme market conditions, more than half of which have already been paid to us in Q3.
We also had higher sales in Latin America and India where normal terms extend beyond the quarter end. These additional factors will unwind over the following two quarters and as such, we are maintaining our full year guidance for adjusted cash from operations at $750,000,000 to $850,000,000 with strong operating cash generation in both the 3rd and 4th quarters. Capital investment through mid year, while lagging the pace implied by our full year guidance, is in line with project schedule. We are maintaining our full year guidance for free cash flow of 3.75 $1,000,000 to $475,000,000 However, we are currently exploring a few product line acquisitions as well as certain though they would further reinforce our growth trajectory. We repurchased 2,560,000 FMC shares year to date at an average price of $78.11 for a total of approximately $200,000,000 It is our intent to remain As Pierre said, we intend to repurchase a total of $400,000,000 to $500,000,000 of FMC shares in 2019.
I note that our full year EPS guidance reflects the benefit of repurchases at the lower end of this range in light of the potential additional investment opportunities I just mentioned. And with that, I'll turn the call over to Mark.
Thank you, Andrew. Over the last few months, we've seen numerous published reports discussing our diamide insecticide portfolio, speculating on the timing of patent expirations and the impact these may have on the long term on the long term profitability and growth of these important active ingredients. I want to take the time today to provide further clarity on not only our patent estate and the timing of key patent milestones, but also on other critical elements that will allow FMC to continue to profitably grow the diamide franchise well beyond the expiration of key patents. These other critical elements include registration and data protection, commercial strategies, brand recognition as well as manufacturing and supply chain complexity. Our diamide portfolio consists of 2 key molecules, rinaxypyr and cyazypyr insect controls, with current combined annual revenues of approximately $1,500,000,000 It's important to note that rinaxipar and cyazipar are FMC's trademark brand names for the active ingredients chlorantirliprol and cyantrliprol.
These two molecules are class leading in terms of performance, combining highly effective low dose rates with fast acting systemic long residual control. These attributes quickly established rynaxypyr as the world's leading insect control technology and we expect it to continue a strong growth trajectory. Moving to Slide 11 to begin our discussion of the diamide patent estate, let me first pause to recognize DuPont. Out of all the quality assets we acquired in 2017, the IP estate and thought that went into building the IP protection of these molecules was extremely well done. Today, I will largely confine my comments to rinaxypyr, though the same comments are generally true for cyazypyr with extended time lines by 18 months.
The rinaxapyr patent study is made up of several different patent families, which cover composition of matter, both the active ingredient and certain intermediates manufacturing processes, both the active ingredients and certain intermediates formulations, uses and applications. For Inaxipir, we have 21 patent families filed in 76 countries with a total of 639 granted and pending patents. Together with cyazapyr related patents, we have over 30 patent families and close to 1,000 granted and pending patents. Composition of matter patents cover the structure of the molecule and are generally the patents that most observers are focused on. Process patents cover the manufacturing processes for both active ingredients, chlorantraliprole and cyantraliprole, as well as the key intermediates that are used to make the final products.
In the case of rynaxypyr and cyazypyr, these process patterns are extremely important. Chlorametreliprole is a complex molecule to produce. In fact, its production requires 16 separate steps, many of which produce an intermediate that sole use is in the production of chlorantroliprole.
This is very important
as it means there are no other commercial uses for these intermediates and hence no other commercial outlets for them. Importantly, FMC has many of these 16 process steps separately patented. Several of these intermediate process patents run well past the expiration of the composition of matter patents and in some cases stretch all the way to the end of the next decade. 3rd parties that intend to manufacture and sell generic chlorantriliprole and cyanriliprole and rely on FMC's product safety data will be required to demonstrate that their product has the same regulatory safety profile as FMC's, rinaxypyr and cyazypyr insect controls. To meet these stringent regulatory requirements for such a difficult to manufacture molecule, the AIs will have to be made the way we're making it, which is protected by FMC process patents.
Process patents can also include manufacturing processes that are not currently used, but are alternative ways to manufacture our diamides. We hold patents on several alternate processes, but it is important to note that these alternate processes do not match our diamide impurity profile. Formulation patents cover the use of an active ingredient in specific formulations, while use and application patents cover how the products are used and how they are applied. In addition to the patent estate, various regulatory bodies around the world also offer added protection to the holder of patented molecules in the form of data protection and registration timelines that can extend after the composition or process patents have expired. This means that the patent holder is afforded a further period of exclusive use after the application applicable patents have expired.
Over the coming slides, I'll show by major country how the patent is state, registration timeline and data protection come together. These highlighted countries currently account for over 70% of our diamide revenue. Turning to Slide 12, you can see how we view the entire time line for Europe. We have 2 parts of protection. First, we have patent protection for the composition of matter through August 2022 and later in certain EU countries.
In addition and importantly, we have patent protection through December 2025 for key processes that are required to manufacture an AXA per. In effect, this means that no one will be able to manufacture or import chlorantroliprole in the EU until December 2025 as they would be infringing our process patents. 2nd, in Europe, owners of patented active ingredients are also granted exclusive data protection, which for chloramtriliprole effectively means a third party cannot use the FMC data to gain a registration for a period of 13 years after the first registration. In addition, a further two and a half years of data protection will be given at the initial re registration of the active ingredient. Practically speaking, this means that no one seeking to register chlorantriliprole can use FMC generated data to apply for registration during the data protection period, which runs through the end of October 2026.
A third party can start to generate their own product specific data for registration purposes during this period. And after the data protection period has expired, they could then apply for registration, which under EU rules should take 18 months, but generally takes 2 years. This multilayered framework means that we will not see competitive sales of chlorantroliprole until Q2 2027 at the earliest in the EU, unless it is sales of products sourced from or under license from FMC. On Slide 13, you can see a similar chart to what we had in the EU with regards to patent protection, but with a different registration process. The U.
S. Does not have the same type of data protection as in the EU. However, under U. S. Patent law, a third party cannot test or generate data or sell a product in the U.
S. Prior to patent expiration. This means that any third party company wishing to gain registration to manufacture and sell chlorantroliprole cannot start the regulatory process until our main process patents begin expiring in December 2025. At that time, the 3rd party company can apply for a federal registration, which under normal circumstances will take about 12 months. After the federal registration has been granted, a state registration is also needed for each state where the product will be sold.
These state registrations normally take an additional 6 months to be granted. In addition, the 3rd party is legally required to compensate the data holder, in this case FMC, for using FMC's data to gain a registration. This robust patent protection and regulatory timeline means that we do not expect 3rd party to be able to sell chlorantroliprole in the U. S. Until June 2027 at the earliest, unless they are supplied or licensed by FMC.
Moving to Slide 14, which shows the timeline for 2 other key countries for diamides, China and India. Similar to other countries we've reviewed, you can see that the AI composition of matter patents expire in August 2022 and the key process patents begin expiring in December 2025. In India and China, a third party can start applying for registration for a product during the timeframe that a molecule has patent protection. However, in both these countries, we have the key manufacturing processes patented, which effectively means that even if the registration is granted, a third party could not start selling competitive chlorantroliprole until Q1 2026 at the earliest. Finally, the last country I will cover is Brazil on Slide 15.
The patent time lines for enaxypyr in Brazil are longer than most other countries. The composition of matter patent on the active ingredient will expire in April 2023 and our key process patents will begin expiring in August 2026. Under current Brazilian regulatory practices, a third party can apply for a registration before the patents have expired. However, Brazil has a law protecting the exclusive use of initial exclusivity falls foul of this Brazilian law. We have initiated a legal process with the Brazilian regulatory authorities to have FMC's data exclusivity respected.
Taking this into account means first competitive sales of chlorantroliprole will not occur before September 2026. Turning to Slide 16. The second part of our growth strategy for the diamide is our commercial approach. It should be very clear that we have an airtight patent coverage for the process of manufacturing the diamides. However, we are also advancing a strategy of allowing others to sell rinaxypyr and cyazypyr insect controls as long as they purchase the active ingredient of formulations from FMC and license the trademarks.
Selling that active ingredients to 3rd parties is a profitable way for us to grow our business as it increases the market reach for the molecule. It is not EBITDA margin dilutive. At a reasonable gross margin, the absence of SG and A expense for FMC means incremental gross margin drops straight to EBITDA. The 3rd party bears all costs related to formulating the active ingredient into a marketable product as well as selling and distributing the product to the customer. As of today, we have commercial agreements already in place or are actively negotiating new agreements with more than 15 companies to supply rynaxypyr and cyazypyr on a global or country basis before patent expiration.
We are continuing to explore opportunities with additional companies beyond the 15 we already engaged with today. The duration of the agreements extends well beyond the patent expiration dates and are exclusive in nature. This means our 3rd party partners will be required to purchase a large majority of their diamide requirements from FMC over the lifetime of the agreement and all their needs prior to the expiration of process patents. The number of companies where we already have signed supply contracts or have ongoing negotiations demonstrates that many competitors would prefer to partner with us rather than attempt to manufacture a complex product that is highly protected by IP. Our commercial strategy ensures that the diamide technologies will continue to gain share.
These new commercial partners will leverage different market access in different geographies and crops with different formulations than FMC has today. These actives will be additive to the overall growth of the FMC diamide franchise. For years past the patent expiration date, FMC will have a growing diamide business with a strong share of the market at the grower level and an even stronger share of the molecule at the manufacturing level. Beyond our significant patent protection commercial strategy, the complexity of manufacturing and scale of economies FMC enjoys are further underappreciated aspects of the long term strength of the diamides platform. Today, FMC manufactures all the required intermediates in the 16 step process as well as the final rinaxypyr products at our own active ingredient manufacturing plants or via partners under exclusive long term agreements.
For a third party to replicate this complex supply chain and manufacturing network would be a major undertaking with very large capital requirements. In addition, given the know how we have and the scale of our operations, FMC's manufacturing costs will be substantially lower than any new entrant. This explains why we are confident most companies that want to participate in the formulated diamide market will choose to do so in partnership with FMC. In closing, I hope I've addressed many any missed perceptions about the long term sustainable growth of FMC's diamide franchise. Our deep patent estate, proprietary regulatory data, manufacturing scale and knowledge, strong brand recognition as well as commercial approach will ensure that FMC is the company of choice to supply diamides to 3rd party partners.
This will further ensure that the diamides franchise continues to be a major driver of value for FMC through the end of the next decade and beyond. With that, I'll turn the call back to Pierre.
Thank you, Marc, for covering that important topic. To conclude our prepared remarks, FMC delivered another quarter of financial outperformance despite the challenging ag environment in the U. S. Volume demand and price increases in other regions around the world are continuing to deliver strong revenue and EBITDA growth. At the beginning of this month, we successfully launched a new SAP system with a pilot in Brazil.
The new system is performing very well. 20% of FMC now operates on the new S4HANA system and we expect to complete the full implementation in Q2 2020. The Brazil launch is a major milestone in the implementation process, which is giving us strong confidence that we will be able to implement the full system without disrupting our operations. In May, we indicated that we would provide an update on the R and D pipeline on today's call, but we felt it more important to dispel misperceptions about our diamide franchise. Rather than squeeze an R and D update into a future earnings call, we will have more comprehensive and in-depth R and D investor event in the first half of next year.
FMC remains well positioned to outperform the industry and a focus on crop chemicals and biological product is an advantage. Short term execution is delivering superior quarterly results and we are confident that our current portfolio and technology pipeline will deliver longer term growth. I will now turn the call back to the operator for questions. Thank you for your attention.
Thank you. And we'll go to the line of Chris Parkinson with Credit Suisse. Please go ahead.
Great. Thank you. As we enter 2020, you have a few moving parts on the cost front, including a new baseline for raw materials, just given all what's happening in 2019, the SAP, which you mentioned, as well as the role for the TSA among a few others. Can you just update us on your thoughts regarding the setup for the second half and also just into 2020 kind of run rates, etcetera, your general line of sight into these variables and your conviction on your ability to drive margins higher? Thank you.
Sure, Chris. As you know, we had adverse cost and the part of those costs will not be seen next year. So we know we're going to start 2020 with a tailwind from a cost standpoint and also from an FX standpoint. There is also the fact that we are expecting to get out of the TSA with DuPont and set up by Q2 2020, the new S4HANA system. I look at 2 buckets.
The total cost will be the increase in costs we facing in 2019 will not repeat themselves in 2020, but we will still see only a part of that coming as a tailwind. We have not yet quantified exactly how this will be impacting next year. We knew it will be a tailwind, but don't take the entire cost increase into 2020. From an S4HANA implementation and TSA, we still believe that the cost saving on an annual basis will be in the $60,000,000 to $100,000,000 a year, but we will only see a fraction of that in 2020 and same thing we've not yet quantified. So we have two source of benefits from a cost standpoint, but we're going to need a bit more time most likely at the Q3 earnings call to give you a more quantified number.
The other thing which is positive as we are seeing today and we are pleased with as the cost increase are decreasing in H2 as well as FX, price is sticking quite well. So it's also a third tailwind we will see in 2020. You guys have to give us a bit more time. We're still highly focused on 2019. Those are tailwinds for 2020, but we're hoping to quantify that in the next 2, 3 months.
Thank you. And just on the cash generation front, you put some targets out there, which are kind of in the stark contrast to the old FMC, but obviously in a good way. Can you just comment on your progress on the cash conversion for 2019? What else needs to be done in the second half and into 2021 to kind of further drive that conversion up to a peak level of potentially, let's say, 80 ish percent? Just any incremental color on the moving parts will be greatly appreciated.
Thank you.
Yes, the cash in fact there is not much change on the cash forecast for the year versus what we were expecting. The difference, as Andrew said in the prepared remarks, was Q2 was not as cash generative as we are hoping because we made the commercial decision to support our customers, distributors and growers in Q2 who are facing tough, very challenging time and gave them some a break on the cash collection. A big part of that has been paid as was promised and will be seen in Q3 and Q4. So not much change in terms of the forecast outlook for the year, maybe a bit more weighted to what Q3, Q4 than we're expecting. Andrew, do you want to add anything?
No, I think for the current year, I think Pierre's comments are spot on. I do remind everyone that in the first half of last year, we did have some benefits to working capital that don't repeat related to the DuPont transaction, both on inventories and payables as well as a pretty market step down in past news in Brazil. So that comparison is a bit extreme. I think looking beyond 2019, I do think that long term 80% -ish conversion of free cash flow from net income is still very much in reach. We do need to see a step down in our legacy and transformation spending, which we anticipate as we move past the S4HANA implementation and the finalization of the DuPont integration and continue to drive efficiency and working capital, but very much in reach.
I think this year's the cash flow forecast as Pierre mentioned, staying where we are and really does give us the capacity to commit to large return of capital to shareholders both through share repurchases and the dividend and the flexibility to do some incremental investment depending on opportunities through the rest of the year.
Thank you.
Next we'll go to the line of Mark Connelly with Stephens Inc. Please go ahead.
Thank you. Pierre, every quarter we get questions about whether the diamide growth can continue. I think in addition to the confusion over the patents, there's some misunderstanding about how FMC goes to market with products versus the way the previous owner did. So can you talk about your market penetration and why you're confident about diamide growth?
I think there is not a fundamental difference in the way we go to market versus the previous owner. I think we just have a very different profile in term of the crops to which we sell and the region of the world to which we sell. So it allows us to keep on penetrating markets, which were underpenetrated in the past by DuPont not because there is as much of a difference of approach and you said just because of the fact we are a different company and we are benefiting from positioning crops, which are very strong crops for ronexzapyr and tseuzapyr. There is also the fact that as we said in the prepared remarks, we keep on getting registration especially for selazypyr in multiple countries and that is generating more growth. So when we look at the long term, I would not say that we would continue in the 15% to 25% growth rate of the franchise as we had last year and this year.
But a long range plan we would be doing taking us way into the next 10 years looking for a mid single digit to high single digit growth rate for the diamides is very appropriate. Mark, do you want to add any color to this?
Yes. I think we're not finished with the sales synergies. So that's where a lot of the growth is coming from. So greater market access. As Tia said, for cyazepyr, we had this year we've had 8 new registrations in 8 different countries, both in Europe and in Africa.
We continue to leverage our position with major co ops and distributors in the south of Latin America, in the U. S. And we have our new channel access in India, which is a large market for us. So wherever those niche crops are in terms of what I would consider fruit and vegetables, that's where we're seeing continued growth. So you can focus on Asia, you can focus on the South of Europe, you can focus on the South of Latin America and Mexico.
There is a final point. Maybe this point is a bit different from what the previous owner did. Those are the comments made by Mark. We are looking at rilaxypyr and selaxypyr as a great partnering tool with other companies. And as we said, we have partnership and are negotiating with about 15 companies.
We are allowing those companies under some conditions to sell ronaxypyr and seozapyr in different crops, different part of the world. So those companies are increasing dramatically market reach and allowing us to grow faster. And that is a very profitable way for us to grow the franchise. It's not at all EBITDA dilutive and it's a tool we intend to use for the years to come. I think our competitors understand well the quality of the patent estate and are very willing to enter into those 10 years contract or more to partner with FMC on those molecules.
Thanks, Pierre. I want to follow up with a question about Brazil. You've obviously been exceptionally strong there and that's been a core strength of FMC for pretty much forever. We're starting to see some big retail players and distribution struggle down there and we've got a major North American retailer talking enthusiastically about that market. If we do see the Brazil ag retail market gradually shift to be more like the U.
S, how is that going to affect you in Brazil? And how realistic do you think it is that that happens given the massive differences in market structure down there?
So first, let me make a statement. As a large supplier of crop chemicals to the ag market, we like the U. S. Structure. We do like to have large buyers, well established companies, public or private or co ops, which play by the rules of the time and paying time.
So we are not adverse at all to a market outside of the U. S. Starting to structure itself more like a U. S. Market.
It is not it's good from a cost standpoint, it's good from a cash standpoint, it's good from an operation standpoint. Now I still believe if you look at the size of the growers in Brazil that we will see large distributors at a U. S. Model happening, but it's going to take some time. It's a very big market.
It's a market where there is a large number of large players who are growers. So to see a market where you go down to 5 or 6 or 7 large distributors like we have in the U. S, I don't see that in the foreseeable future. Nevertheless, a transition more to other U. S.
Market is not a negative for us. And Mark?
The only thing I would add to that Mark is, you've got some extremely large co ops in the south of Brazil, which operate in a very similar way to the U. S. Model in terms of scale and breadth of capabilities. So I think in parts of Brazil you already have more of a U. S.
Type model. I do think the market is consolidating in terms of distribution. You are seeing acquisitions and roll ups. I think that will continue, but as Pierre said, I think it will take some time to get to where we are in the U. S.
For instance, but I do see it going in that direction.
And we don't see that as a negative at all.
No, not at all.
Very helpful. Thank you.
And next we go to the line of Frank Mitsch with Fermium Research. Please go ahead.
Thank you so much. And Mark, I appreciate the review of the ronexapurastasia pure patent protection time. Obviously, you mentioned it's $1,500,000,000 in terms of sales today, so very attractive. I just wanted to drill into one of the comments you made that it would be very capital intensive for someone else to duplicate your supply chain. Can you give us order of magnitude of what would be involved there in terms of dollars and cents?
Yes, Frank. Thanks. Listen, it's complex to do because understand that when you have a 16 steps, which for us is done through a series of partners who are manufacturing some of the intermediates and some of the final steps which are made by us. It is a very, very complex network. You would not imagine somebody building that in a short period of time over a single site.
So it would require not only capital spending at the level of the company itself, which intend to, but most likely to find partners to produce some of those intermediates. None of these partners could be the partners we do have today who are in exclusive arrangement with our sales for the long term. The number is certainly it's we have not qualified if somebody would try to replicate all or part of our product. But I'd say for part of the total to see numbers more in the $1,000,000,000 range would not be surprising.
All right. That's helpful. And Pierre, I believe you mentioned that at this point, here we sit on July 31, you have 70% of orders already received to meet your second half objectives. I'm just curious, how does that stand in prior years in terms of the percent of orders that you would already have in house? Is that somewhat typical?
Or is that a higher than normal sort of percentages?
It is the same as last year, which was a very strong year. So I would say the last 2 years, we reached that 70% number. Usually, by this time of the year, we're about 50%, 40% to 50%, maybe 40% range at this time of the year. Last year for the first time, we hit the 70% range, which was positive and resulted into a very strong second half. And once again, this year, we are at the same place.
So we view that as a positive versus a normalized year.
We do have a question from the line of P. J. Juvekar with Citi. Your line is open.
Yes. Hi, good morning.
Hi, Steve. Given the delayed planting, inventories in the channel, question on that. If I look at your inventories, they're up year over year, so like compared to Q2 of last year. So was there any missed early application that led to inventory increase and where do we stand about inventories? And the reason I'm asking is, couple of years ago, we had this inventory situation in Brazil that was painful and took some long time to get that inventories down.
So how do you compare that situation? Thank you.
Sure. So, first of all, let me make a comment. Outside of North America, we are in low to normal level of inventories. So we currently have a situation in Brazil. Actually, we have a new process in place, as we said before.
I think it's the lowest ever level of inventory in the channel we are having. In other part of the world, we are under a more normal situation. We recognize that there was missed application made plans, which are made plans which are contemplating not selling some product which will already be in inventory at our customers or in the channel or we have also accounted for returns. So that's the place where we are facing fundamental difference from Brazil in 2015. Brazil in 2015 was a consequence of a process from all of the ag players over multiple years.
We had multiple years of selling too much into the channel. Here, it's a more isolated event over this year because of weather conditions. So we have a year which is difficult versus multiple years in 2015 where the channel was too loaded. So it is not good, but it is manageable accounted for in our forecast, but we are still watching it. Marc, you want to say?
Yes. P. J, the only nuance I would put to what Pierre said about the U. S. Is, the U.
S. For us is really 2 core markets, what we call the heartlands, which is the Midwest, mainly row crop business, and then the horseshoe, which stretches all the way from California through the southern states up the East Coast. Very different situation in those two markets. I would say where we know we have or we think we have higher channel inventories is in the Heartland on the row crops where we believe pre emergent herbicides were missed in certain areas. But in the rest of the U.
S. Where all the niche crops are grown, we're in absolutely normal conditions. So it's very, very isolated to that part of the U. S. And that part of the business.
Great. Thank you. And a quick one for Andrew. Andrew, you mentioned extended terms of payments in the U. S.
For growers. Can you talk about when did you do that last time and what was your experience back then? Thank you.
Yes. I think we've done it on a very limited basis in the past. Our experience has always been that we catch right back up as agreed. And I think as I mentioned, over half the accommodations we gave in Q2 have already been paid at this point in Q3 and the rest will be cleared out by year end. So really just trying to support our customers as they work through their quarter end in what's been a tough year.
But historically in this year, I think no concerns about collection timing or ability on that.
That. Just a quick comment, P. J. I mean, we made that decision. It is not something we've done in the past or we used to do.
It was just exceptional to this, especially in the Midwest. Customers were facing situation where we felt we had to support them. Lots of them, as we said, are big corporation. They live by their word. They pay when they say they will repay.
And as Andrew say, half of it has already been done with a very precise schedule. So no concern, it's an exceptional situation, but no concern on that front.
Next we move on to the line of Vincent Andrews Morgan Stanley. Please go ahead.
Thank you very much. A question on the CapEx potential expansion in diamides. Just wondering is that decision a function of sort of your assessment of how much incremental inventory you want to have for your own needs? Or is it a function of perhaps as you referenced in the patent discussion, maybe extending some of the license agreements or creating new license agreements with other interested parties? Or is it a bit of both?
And is this a significant capital expenditure? What time period would be over and potentially where would it be located?
The CapEx increase we are looking at today are simply due to the fact that when we made our capital 3 year capital spend plan when we acquired the DuPont business, as you remember, we were forecasting a high single digit growth rate for those products. We've been in the 15% to 25% range since the acquisition. So we are getting tight on capacity. Those are not big capacity. It's for part of the chain of manufacturing where we're doing it, especially including some of the intermediates.
You're talking about tens of 1,000,000 of dollars. I'm not talking 100 of 1,000,000 of dollars for the one which are taking place potentially this year. And as we said before, from a location standpoint, we have a couple of locations. But as we said before, the idea for us is to manufacture as much as we can today outside of China. So those expansion will take place outside of China.
It's not huge, but it's necessary ensure we can keep on growing at the speed at which we are growing.
And if I could just follow-up, there's been a lot written recently about armyworm infestation in new geographies. I would assume that is an attractive opportunity for your diamides portfolio. So is that something that you've already contemplated sort of as we think about your long term growth rate or would that be incremental?
Yes, it definitely is. The diamides are right at the top of the tree when it comes to impacting fall armyworm. We've seen the growth of this pest in India. We see it in China and it's now moving through Southeast Asia, Vietnam, Thailand moving south. So we already have in our forecast some incremental revenue from rinaxipar essentially in those countries, but we believe there's more upside as this pest becomes more prevalent, especially throughout the rest of South Asia.
Ladies and gentlemen, just in light of the time, we would ask that you please limit yourself to one question now going forward. We'll go to the line of Joel Jackson with BMO Capital Markets. Please go ahead.
All right. Downgraded one question. Thanks, guys. I'm just kidding. Okay.
So you've guided down the market growth to about flat. So on rough math, to me, that would be like $100,000,000 or $200,000,000 a year excuse me, dollars 100,000,000 to $200,000,000 of headwinds on the sort of top line macro pressures. You've maintained your guidance like you said despite that. Can you talk about what's offsetting some of that pressure down on the macro? Thanks.
Yes. I think the pressure down in the market is mostly driven by North America as we said. So what does it do to us? If you look at the disproportionate strength of our business versus many competitors outside of North America, plus the fact that within North America, we do have a very balanced crop profile with lots of specialty crops. This slowdown of the world growth in ag is impacting us not as much as it could impact other competitors.
So yes, it is a bit of a headwind, but you know what, we are very well positioned to compensate that either by going more into specialty crops in North America or by using the strength of a business in place like Brazil, Latin America or India. Remember, as we said, we only do 25% of our business in North America. So all in all, it's balancing out quite well for us.
Next we go to the line of Don Carson with Susquehanna Financial. Please go ahead.
Yes, Mark, a question for you on these commercial arrangements you're negotiating with other parties, you say you've got up to 15 now. What is the margin profitability on that? And then as you bifurcate that into supplying generic AIs post patent, What's the margin implications for that versus selling your own branded product?
So, Don, we don't obviously give out the margin expectations, but what I put in my prepared remarks were the fact that when we have these agreements and we make these sales, they're not EBITDA dilutive to our overall business. So when you think about it, they're a highly profitable marketing exercise for us. Now on a pricing standpoint, again, I'm not going to disclose the types of conditions we have in these various contracts, but they are very long term in nature. And obviously, these the prices that we agreed with our 3rd parties allow them to make a more than adequate margin on their sales. So both parties are compensated for what we're doing in the marketplace.
So the bottom line is these are highly attractive relationships for us and our 3rd party partners, and they're there for the long term.
Let me quantify a bit by using information we've already shared with you. As you know, we do have depending upon the quarters an EBITDA margin for this business in the 27%, 28%. This EBITDA margin of course is driven and we've said that when we made the acquisition of DuPont with the diamides which are expected to be north of 30% from an EBITDA margin. That's what we are able through this process to protect. So we are selling this product, the active part to a partner and it's generating for us with limited SG and A spending and R and D and formulation spending an EBITDA margin north of 30%.
Next we go to the line of Laurence Alexander with Jefferies. Please go ahead.
Heather, just one last one on the diamide discussion. As you've looked at the manufacturing chain that already exists for these products, and FMC's historical approach to reengineering the chain and finding new manufacturing partners. How should we think about the 5 to 10 year opportunity for bringing down the cost of manufacturing? And should we see that in terms of lower market prices, so basically protecting the growth rates and protecting the margins? Or should we see it as margin expansion over time?
Yes, Laurence. I mean we have our whole engineering group looking at the diamide manufacturing processes and looking at how we can bring cost down over the mid to long term. So that's certainly something that we're not going to let pass. We know how to do this. We've done it very successfully with not our not only our own molecules, but other molecules as well.
I wouldn't comment on this point about price volume relationships in the marketplace going longer term. And in today's world, you know, these molecules are high for their cost in use. So right now we're growing the market at the right margin at the right price. I don't see that changing in the near term at all. So whatever we get in terms of manufacturing cost reductions over the midterm will stay within FMC.
And we've already done in 2 years, in 2 years we've already done multiple debottlenecking, brought new partners into the process. So we are already actively increasing capacity at very low cost. You've not seen a major increase so far in capital spending despite the fact that we've already increased our capacity in a significant way for diamide. So your point is correct for both cyazapyr and rolexapyr, we are doing it and intend to continue to do it.
And our last question is from the line of Kevin McCarthy with Vertical Research. Please go ahead.
Good morning. Thanks for squeezing me in. A 2 part question on your capital budget. The first part is that you affirmed your range for the year at $140,000,000 to $160,000,000 yet you've spent only $34,000,000 in the first half. Looks like the last couple of years of spend has been quite back end loaded.
So I was wondering if you could speak to what is driving that kind of quarterly cadence, number 1? And then number 2, do you have any preliminary thoughts on how the budget could trend in 2020 versus 2019?
So from a capital spending, I've been doing that for years now and I think it's been the same thing year after year, which means usually you start your big project, lots of your big projects are starting with the beginning of the year when you start with the new capital spending. So you usually have a process where there is a lot of planning and engineering study, which do not represent a lot of spending and then it accelerates by the middle of the year when things are already put in place and you start to spend the cash. So I don't think there is anything abnormal, I must say that. 70% or 80% of my years in the industry have always seen back end loaded big engineering product and capital expenditure. I think for next year today, we've not been yet through the process.
We believe we'll have a higher capital spend, mostly due to capacity increase for the product we are commercializing, new product or the existing product as Bayer made.
Yes, Kevin, the only thing the additive piece to what Pierre said is basically we have 2 new active ingredients that are coming out of our pipeline that come to market in 2021. We're putting steel in the ground next year for that capacity expansion. So it's a combination of both current products and new pipeline products.
So you'll see a slightly elevated number next year for capital spend. That's all the time
that we have for the call today. Thank you and have a good day.
Ladies and gentlemen, this does conclude the FMC Corporation conference call. Thank you for your participation. You may now disconnect.