Good day, and welcome to the Polaris First Quarter 2021 Earnings Call and Webcast. All participants will be in a listen only mode. After today's presentation, there will be an opportunity to ask questions. If you have further questions, you may reenter the question queue. Please note this event is being recorded.
I would now like to turn the conference over to Richard Edwards, Head of Investor Relations. Please go ahead, sir.
Thank you, Chuck, and good morning, everyone. Thank you for joining us for our Q1 earnings call. A slide presentation is accessible at our website at ir.polaris.com, which has additional information for this morning's call. Mike Speetzen, our Interim Chief Executive Officer and Bob Mack, our Interim Chief Financial Officer, have remarks summarizing the quarter and are revised Expectations for the full year, then we'll take some questions. During the call, we will be discussing various topics, which should be considered forward looking for the purposes of the Private Securities Litigation Reform Act of 1995.
Actual results could differ materially from those projections in the forward looking You can refer to our 2020 10 ks for additional details regarding these risks and uncertainties. All references to the Q1 2021 guidance are reported on an adjusted non GAAP basis unless otherwise noted. Please refer to our Reg G reconciliation schedules at the end of this presentation for the GAAP to non GAAP adjustments. Now, I will turn it over to Mike Speetzen,
our Interim CEO. Mike? Thanks, Richard. Good morning, everyone, and thank you for joining Once again, the Polaris team delivered an impressive quarter despite substantial supply chain challenges. Our team has remained focused on meeting the needs of our dealers and customers, which allowed us to again beat expectations this quarter.
Before we get started, I wanted to thank the entire Polaris team for their focus, dedication and execution This past quarter was truly impressive. Consumer interest in powersports continued at record levels throughout the quarter with strong growth coming from both Existing customers and new customers. I'm pleased to report that our ORB market share gains continued, which we expect to be an ongoing trend for the year. I'm also pleased to report that motorcycles, snowmobiles and boats also had strong retail demand and gained share in Q1. The strong growth we are experiencing is not only in our North American whole good retail.
Our PG and A business grew nearly 50% during the quarter with all segments and categories up significantly year over year. And our international business was also strong with sales increasing 59% impacted by the pandemic slowly began to reopen. Q1 results reflect an all out effort by the Polaris team to overcome numerous challenges. We continue to operate our plants at maximum supply chain constrained capacity and utilize every available tactic at our disposal to produce While our dealer inventory remains below optimal levels, we largely met demand and expertly navigated supply chain constraints. To do so, logistics, commodities and rework costs have increased substantially.
We are managing the cost as best we can and where it makes strategic sense have raised prices compensate for this inflation. And yet, despite these headwinds, given the overall strong and better than expected performance seen in Q1 And continuing into April, we are raising our full year guidance. Bob will give you more details shortly. 1st quarter North American retail sales were up a robust percent, continuing the unprecedented levels of growth. The comparables were easier in the last 2 weeks of March when the pandemic drove an abrupt shutdown of commerce in 2020.
Even after adjusting for that impact, our retail was up an impressive 50 plus percent for the quarter. We continue to see an expanding customer base with new customers growing 70% in Q1. We are especially proud to see success in our strategy to further diversify our customer base. While many of these new customers have been in powersports for only a short time, our early data indicates a strong intent of these new customers to stay with the sport and a stronger intent to purchase another vehicle versus what we have historically seen, which is a promising indicator to support ongoing strong retail And the continued growth in sales to our existing owners, which increased an impressive 40% year over year, reinforces our confidence that these customers will return. As I indicated earlier, our ORB business gained over 4 percentage points of market share in the Q1.
Both Indian and Slingshot's 1st quarter retail was Strong as well, collectively finishing up over 70% and market share increased about 3 percentage points. Boat retail was also strong, tracking ahead of the industry based on performance of our snowmobile business. While our snowmobile business is one of our smaller product lines today, it is where we started over 66 years ago in Northern Minnesota. The The North American snowmobile industry concluded its strongest season in over a decade with industry retail up approximately 16%. Polaris Retail eclipsed the market, growing in the mid-twenty percent range, resulting in market share gains of over 2 points for the season, the best share position in 16 years.
We are seeing tremendous new customer growth in snowmobiles. During the 2020 2021 selling season, new customers represented over 60% of the sales growth, nearly double the rate from the prior season ending March 2020. During the quarter, we held our annual spring dealer meeting While virtual, it was one of the best attended meetings in over a decade. Attendance was up almost 80% compared to 2020. During the meeting, we introduced 22 new snowmobiles on the revolutionary Rider First Matrix platform, which delivers industry leading ride and handling both on and off Additionally, we introduced the company's first turbocharged 2 stroke engine, the Patriot Boost.
This new engine uses proprietary SmartBoost technology for unrivaled combustion stability, enabling 10% more power at sea level and 50% more power at 10,000 feet than our current 850 Patriot engine. The strong model year lineup along with continued demand from new customers entering the sport has generated demand we haven't seen in years. In fact, our snow check orders, which concluded a couple of weeks ago, will make up over half of our snowmobile build this year, eliminating much of This has continued to pressure our ability to fill the dealer channel. Inventory levels declined further on a sequential basis and we are working all available options to ease the supply chain strain as quickly as possible. I'll talk more about our efforts to manage the situation shortly.
As we've discussed in the past, pre sold vehicles continue to be a lever that our dealers can utilize to ensure they capture the sale. This is enabled by our advanced manufacturing capability, which provides visibility into and flexibility of our production plan. This is just one of many examples of how the team is navigating this Challenging environment to ensure dealers and consumers get the vehicles they want. Given the current environment and our expectations That the supply chain constraints may not improve significantly until late in 2021, we anticipate it will likely take Supply chain through 2021 positions us well to meet consumer demand. The number of suppliers impacted by COVID related has been somewhat of a moving target.
The Polaris team has been doing a tremendous job of keeping product flowing to fulfill demand by expediting shipping, Working directly with suppliers on their staffing and supply base, rebalancing in source and outsource manufacturing, using alternative logistics lanes to shorten lead times, staging Polaris employees at ports to expedite customs clearance and optimizing the flow and location of inventory to fill backlog Additionally, we're adding capacity at select locations, including Monterrey, Mexico for RZR and General Elkhart in Syracuse, Indiana for Bennington and Hurricane Rigby, Idaho for Klim Apparel and Wilmington, Ohio for PG and A Distribution. We will be evaluating additional expansion needs with our Board as the year progresses based on the trajectory of current demand. These additions along with the anticipated supply chain improvements later in the year will allow us to further ramp production in the coming quarters. However, as I said before, we Do not see dealer inventory returning to targeted levels until sometime in 2021. Despite these distractions, I'm happy to report that we are still on track with our supply chain and that the savings are being realized slightly ahead of plan.
This is an incredibly important strategic initiative for us with the goal of identifying suppliers that can provide the best quality, delivery, service, technology and value. We have now made all sourcing decisions 2 of the 4 waves and we kicked off the 3rd wave in February through a virtual supplier conference and are optimistic about the continued success of the program. By the end of the year, we expect to be almost halfway to our goal of approximately $200,000,000 of gross savings. Currently, these savings are partially offsetting increased costs from logistics, Commodities, rework and tariffs. The good news here is when these costs abate, our sourcing savings will continue.
Powersports electrification is a very real opportunity, appealing to current as well as new consumers. As we look into the future, EV technology will Our efforts today will set the stage and enable us to be well positioned Our revved up strategy aims to position Polaris as the industry leader in electrification, both through the introduction of new vehicles and expansion of current offerings. Our goal is to offer consumers an electric vehicle option within each of our core product segments over the next 5 years. Last fall, partnered with 0 Motorcycles, a global leader in electric motorcycle powertrains and technology to bring to market an all new 2022 electric Ranger by December 2021. This all new electric powertrain will elevate the Ranger platform to a whole new level of capability, durability and performance.
We're also making investments to grow our current EV offerings with the co development of a fully autonomous low speed shuttle using our JEM vehicles coupled with Optimus Ride's full stack sensors and software to enable fully autonomous shuttles. The vehicles are expected to roll out in the second half of twenty twenty three. As we move through the year, watch for additional details on our revved up strategy and the upcoming Ranger product launch. I'll now turn it over to Bob Mack, who will summarize our Q1 results and our updated expectations for 2021. Bob?
Thanks, Mike, and good morning, everyone. As you just heard, our Q1 far exceeded our Thank you, David. Given the ongoing strong retail demand across the portfolio. The Polaris team has met the challenges of supply chain shortages, logistics delays by working tirelessly with our suppliers, executing significant rework and coordinating with our logistics providers to deliver on our dealer and customers' expectations. 1st quarter sales were up 39% on a GAAP and adjusted basis versus the prior year.
Sales were up significantly for all segments of our business, driven by the ongoing strength in powersports, the boating industry, in our adjacent markets and aftermarket segments. 1st quarter earnings per share on a GAAP basis was 2.11 Adjusted earnings per share was $2.30 which was up significantly over last year's Q1. The results were driven by increased volume across Portfolio, lower promotional cost and operating expense leverage during the quarter. Adjusted gross margins were up 3 52 basis points year over year, primarily due to the lower promotional costs driven by the strong retail demand and lower floor plan financing costs as a result of the low dealer inventory levels. Supply chain constraints were an ongoing pressure point to gross margins as logistics and rework remained high.
And as we previously indicated, tariff costs were higher during the quarter as the one time exemptions and refunds we saw in 2020 largely ended. Operating expenses as a percentage of sales were down 5 84 basis points as we realized leverage from the strong sales growth and the timing of some R and D expenses And stock based compensation costs being delayed into the coming quarters. Income from Financial Services declined 18% during the quarter as income from the Polaris Acceptance joint venture, which dealers use to finance their inventory, continued to be down due to the lower level of inventory in Foreign exchange also had a positive impact on our quarterly results, primarily driven by the Canadian dollar and the euro. From a segment reporting perspective, all segments reported increased sales for the quarter. ORV and snowmobiles increased 50%, Motorcycles increased 31%, Global Adjacent Markets was up 27%, Aftermarket increased 14% and boats increased 29% for the quarter.
Our segments benefited from lower promotional costs, which Has decreased considerably across the powersports industry given the high demand and the lack of product in the channel. And aside from boats, all powersports segments also experienced a negative product mix during the quarter as supply chain constraints caused a shift in the types of products we were able to produce. Two additional highlights I want to point out are our international and parts, garments and accessories businesses. International sales were up 59% during the quarter. All segments and regions experienced increased sales during the quarter, mostly driven by strong ORVs, snow, motorcycle and PG and A sales.
About 10 points of the growth came from improved currency rates. And our parts, garments and accessories sales increased 49 During the quarter, all segments and product categories grew significantly during the quarter, driven by strong retail and installed base demand. Moving on to our revised guidance for 2021. Given the stronger than anticipated performance in the Q1, We have increased our total company sales growth guidance and now expect sales to increase in the 18% to 21% range for the year, up from the 13% to 16% we guided in January. We are also increasing our full year adjusted Earnings per share guidance for 2021 and now expect earnings to be in the range of $9 to $9.25 per diluted share.
The increase is driven by higher volume, increased pricing through growth MSRP changes and continued lower promotional spending and floor plan financing costs, in addition to improved foreign exchange rates and operating expense leverage. These positives are, however, being partially offset by continued manufacturing inefficiencies and higher logistics costs to commodity and component pricing pressures driven by supply chain constraints. While we are pleased with the strong demand we are experiencing, It continues to stress our supply chain as our supply partners attempt to match our demand trends. This is putting additional pressure on gross profit margins for the remainder of the year. We now anticipate that gross profit margins will be down 60 to 90 basis points, Primarily driven by ongoing negative product mix we saw in the Q1, along with increased logistics and manufacturing inefficiencies due to the high level of rework in our factories.
Additionally, we are seeing increases in commodity prices that we expect to hit our P and L beginning in the second quarter. As a result, we are implementing price increases to help offset these pressures. However, we expect it will take several quarters for 2 to converge. And as Mike indicated, our supply chain initiative, now in its 3rd year, will help offset some of the additional supply chain costs. While our gross profit margins are expected to be down for the year, as I stated on our last earnings call, if you exclude the impact of tariffs and supply chain disruptions, Our gross profit margin rate would be up over 200 basis points compared to last year.
Adjusted operating expenses Are now expected to improve 80 to 100 basis points as a percentage of sales as sales growth outpaces operating expense growth. Our guidance for operating expenses in dollars for the full year hasn't changed. The improvement in operating expenses as a percent of sales Entirely driven by the escalating sales growth anticipated this year. Income from Financial Services is now expected to be down in the high single digits percent driven entirely by the expectation that dealer inventory levels will remain low. Retail financing availability remains at acceptable levels.
Guidance for the remainder of the P and L items remains materially unchanged from our previously issued guidance. Given our strong performance in Q1, our expectation for sales and earnings per share are relatively consistent across each of the next three quarters. Seasonality of products will have some impact, but in general, we will produce be producing the maximum number of vehicles our supply chain will allow. As I mentioned earlier, we expect supplier constraints to continue to negatively impact our sales mix. Additionally, higher commodity costs will begin to materialize Q2 and are expected to remain for the balance of the year.
Both of these factors will result in lower gross profit margins as compared to the Q1. We expect operating expenses in each of the remaining three quarters to be approximately 10% to 15% above Q1 given the timing of spending. Moving on to sales expectations by segment. The increase in total company sales is driven by the sales increases in all of our businesses, given the strong first quarter demand and significant order backlog. As we have stated, the gating factor in meeting the current demand and beginning to fill the dealer channel is the ability of our supply chain and logistics network to be able to deliver materials to the factories.
Our operations and sourcing teams continue to work diligently to maximize production levels. 1st quarter operating cash flow finished at $56,000,000 compared to a negative $71,000,000 in the Q1 of last year. While our first Quarter is typically a heavy cash use quarter given the working capital timing. Our strong cash from earnings was able to overcome the cash needs and provide positive cash from operations. Our cash flow performance expectations for the full year remain unchanged as we work to rebuild dealer and factory inventory to more acceptable level.
Our bank leverage ratio improved sequentially to approximately 1.3 times as our debt levels continue to decline as anticipated. Our expectations for use of cash for 2021 outside investing in the business remains a combination of debt reduction and share repurchases. During the Q1, we spent almost $300,000,000 on share repurchases. Of the $300,000,000 spent, $130,000,000 was generated from the exercise of options. This helped to minimize the dilution of our shares.
We anticipate continuing to buy back shares throughout the remainder of the year, subject to market conditions and available authorizations. Our expectations for capital expenditures of approximately $250,000,000 remain unchanged. And on January 28, the Board of Directors approved a 2% increase in the regular quarterly cash dividend, which is the 26th consecutive year of Polaris increasing its dividend. With that, I will now turn it over to Mike for some final
Thanks, Bob. During the quarter, we experienced broad based retail strength across all of our businesses. New customers Keep pace with demand trends will remain an ongoing challenge for longer than originally anticipated, but our size, agility and seasoned Polaris team gives me confidence in our ability to match supply with demand better than anyone in our industry. The company is in the best financial position in years with a strong cash position, depth below our targeted leverage ratios and all segments expected to grow sales, improve profitability and gain market share in With that, I'll turn it over to Chuck to open the line for questions.
Thank you. We will now begin the question and answer session. And at this time, we'll pause momentarily to assemble our roster. And the first question will come from James Hardiman with Wedbush Securities. Please go ahead.
Hey, good morning. And great job on obviously a tough quarter guys. So similar to last quarter, my new favorite slide or graph as this capacity utilization graph. Maybe walk us through that in A little bit more detail. This is Slide 8 I'm referring to.
When I look at that, this critical question of inventory, Seems like you think that capacity will expand in the second quarter and maybe meet demand that you'll be able to build a little bit of Dealer inventory in the Q3, but then in 4Q, we're going to fall meaningfully short of that again, and we'll probably finish the year in a worse Inventory position than we started. I don't know if I'm reading too much into that. There's a lot going on of information trying to be conveyed there, but maybe walk us through the key assumptions there.
Yes. Thanks, James. A couple of things. We put that red line on the graph To highlight the fact that we are running the factories at full capacity, but we use the word supply chain constrained for a reason, Because, we're dealing with producing vehicles partially complete. For example, when phone became a huge issue, We're rolling vehicles off the line without seats and then we're reworking those vehicles.
Our rework rates are pretty high, but the team is doing a really good job of making Sure that we're doing that in a high quality manner. Really, the supply chain is what's constraining us right now. I will tell you the Team, as I indicated in my prepared remarks, has done an outstanding job. Supplier issues with semiconductors come up. We're knocking them down.
The team has been incredibly agile and going after that. We will make progress on dealer inventory from where we are today. It will increase as we go through the year based on the retail expectations that we have right now, and that's really going to be predicated on us continuing to push the Supplier issues down and get the manufacturing ramped up as much as we can. Some of the capacity that's coming online is Going to help us here in the second half in terms of just being able to manage and digest the volume, but overall I feel really good about where the team is at and We can't see into the future and understand what the issues are going to be around potential supply chain problems, but I'll tell you based on what the team has done thus far, I've got a lot of confidence. I made some comments in the Q1, in January call around, we are not going to Try and save money in the face of significant consumer demand.
And so, whether it's logistics or Supplier work that we're doing, we're going to put the investment in the money and then you're seeing that come through in the margin profile. The good news is That this will abate at some point in time and we'll see that favorability come through from a margin perspective.
That's really helpful. And then maybe just a quick follow-up, if I may. Selling and marketing, at least versus where the Street was, was a big beat. Some of that is Presumably that you have this supply demand imbalance that's pretty favorable right now. I guess, how do you think about that particular line item for 2021?
And then What's sustainable? As we go forward, I don't know, whether on an absolute dollar basis or a percentage of sales, Like what does that line item look like once we're past this crazy phase that we're in?
Sure. James, it's Bob. So I think if you think about OpEx, really the impact you see in the Q1 is really one of Timing. So we're forecasting expenses for the year to be flat and we feel good about that's a reasonable level to use to run the business. So the 80 basis points to 100 basis point benefit is really just based on the sales leverage.
The timing issues in the quarter, which sort of turnaround later in the year are mostly some delayed spending on the engineering side just as different projects move around And then some stock based comp that normally would have been recognized in Q1 that hasn't been recognized yet that will show up later in the year. So They're not things that will repeat themselves in the future. So it's kind of a 2021 anomaly. So I think you should think about the OpEx being flat for the year in dollars.
Got it. But should we assume a step up after this year? I mean, To some degree, for sales to be up as much as they are and that OpEx line to be pretty flat, I'm assuming that at least a portion of that is a function of the promotional environment, the favorable promotional environment we find ourselves in, which doesn't Seem like it's really sustainable.
No, I mean, James, the promotional stuff falls through the gross profit and Bob can certainly talk about some of the dynamics Relative to that as we look out into the future quarters when we think promo will start coming back. I think Bob hit Timing, as we go forward, the sales and marketing investment is something that we're going to continue to have as a high priority. The work we've done around attracting new customers is incredibly important. What I will say is the team has gotten even more efficient. The investments we made around our Customer relationship management system, the data analytics tools.
I was walking through with the team yesterday the work that they had done around new customers and we go back and we measure their repurchase rate in the next 3 months and we do that on a 3 months, 6 months, 1 year, 5 year, 10 year basis. And the amount of data and analytics that they have, that helps us Because now we can take that data and be a lot smarter about where we do target promotion as well as where we're spending money, whether it's media campaigns or Advertising on TV and I think that will continue to be an efficiency for us, but I think on an absolute dollar basis, it will continue to grow into the future.
Got it. Thanks guys.
Thanks.
The next question will come from Craig Tennyson with Baird. Please go ahead.
Hey, good morning. Thank you for taking my question. I wanted to deconstruct the incredible retail growth in the quarter. I wonder if you could maybe characterize the mix as it relates to first time buyers, maybe your core Repeat buyers. And then to what extent are there first time buyers from last year that may have said, hey, this is great, I want to buy another one and get my family involved, Thanks like that.
Yes. Hey, Craig.
The mix, as I indicated,
I mean, the growth was Our new customers grew at 70%, our existing customers at 40%. And as I was mentioning in that Prior discussion with James, I went through with the team yesterday the repurchase rates. We started watching this given the surge in demand in 2020. And Yes. I think one of the concerns we had was, where we're going to have a bunch of people come in and then they lose interest.
And the interesting fact is that the Repurchase rates as we look at our 2020 new customers versus say 2019 or even 2018 new customers, They're actually repurchasing at a substantially higher rate, meaning they're coming back in 3, 6 months, 1 year, and repurchasing or buying another vehicle and that's very encouraging, especially when you add that to the existing customer base, that we've had for years is coming back in strength, as I mentioned Earlier 40% year over year improvement and it's substantial. And I know that there's a lot of concern around where is retail headed for the And I think on a relative 2020, we think retail is going to be kind of flattish and it will be down a little bit in RV, up a little bit in motorcycles but down. But the point I would raise is we are seeing continued strength through the year relative to 2019, and that's important when you think about Where the industry was, the surge we saw in 2020, this is not retreating back. We expect we'll be up probably 20%, 25% from a retail stand We will now take our next question from the line of Mattressman from Morgan Stanley.
Boyd:] Thank you, Mattressman from Morgan Stanley. Boyd:] Thank you, Mattressman from Morgan Stanley. Boyd:] Thank you, Mattressman from Morgan Stanley. Boyd:] Thank you, Mattressman from Morgan Stanley. Boyd:] Thank you, Mattressman from Morgan Stanley.
Boyd:] Thank you, Mattressman from Morgan Stanley. That I mentioned earlier as well as evaluating potential capacity additions into the future.
Thanks. And are you able to Measure in any way the impact of stimulus checks as they come into the economy?
It's tough. I mean, we've have gotten that question a lot. I guess I characterize it as it's just fuel to the economy and to what is already a very strong consumer savings rate. And I think if you look at our we've gone through our demographics and our customer profiles with investors over the years. And For the most part, our customers were really stable through the pandemic in terms of their employment level didn't change.
They were collecting stimulus money, stock market is up, most of them obviously have 401s. And so the financial stability and strength of our customers has certainly Been an equation in this, but to be able to try and correlate the stimulus check itself back is tough to do.
Great. Hey, thank you.
Thanks, Greg. The next question will come from Brett Andress with KeyBanc. Please go ahead.
Hey, good morning. Just a question on some of the selective pricing that you're taking. Is there any way to quantify how much price You're passing on right now. And then maybe how much price you need to take or you plan to take in theory to offset some of the gross margin pressure.
Sure. So the announced price increase In ORV, it was about 2.5%, and that's obviously the biggest factor for us, biggest part of the market. And that comes into effect May 1. So we'll start to see that in Q2 and through the balance of the year. In terms of the offset, The offset really is a combination of price, lower promo, lower finance interest, not just price.
And so right now with that increase, we're basically offsetting the cost of the increased logistics and the commodities, but it's on a dollar basis. So you lose a little bit in the gross from a gross margin percentage basis. We'll continue to look at price. I mean, obviously, it's tough to forecast commodities and logistics for the full year. We're in a little bit of unprecedented times, particularly from a logistics standpoint.
Things are moving around pretty violently. So we'll continue to look at pricing through the course of We have model year introductions coming up in August, so that should give us another opportunity. And so we'll continue to consider that as the year progresses.
And Brett, I would just add that The pricing moves have been incredibly strategic. I give the team a lot of credit for doing the work rather than just Implementing a broad based price increase, they've been very specific around models. So we have some models that won't get touched. We have other models that may be higher and whether that's ORV, motorcycles or boats. And then, we've also added freight surcharges, which obviously as some of the logistics Issues abate in the future, that's obviously a toggle point for us with the dealers.
Got it. That's helpful. Thank you. And then maybe building more specifically to, I think, James' question. I think the plan last quarter Was the end 2021 channel inventories down 20% to 30% below optimal levels?
I guess with everything that we're seeing so far in 1Q, Where does that target stand now? And then any commentary you can share On April retail trends here.
Yes. So the way I'd characterize it is the Q4 dealer inventory is going to be lower than we were expecting But it will we're going to the plan right now is to improve it from where we stand today about 30%, 35%. And so we will see We'll start to gain a little bit of momentum. But as I said in my prepared remarks, it's going to take us into sometime in 2022, and Obviously, we'll continue to refine and work that as we get later in the year. April, I think 1st and foremost, The expectation is we'll be down versus last year, just given how strong the Q2, I'll remind you, we were up 57% in retail last year.
So That's a tough comp. But the month of April has been performing better than we expected, and the retail is holding up And the team is doing a great job of expertly navigating that. And even though we expect the full quarter to be down versus where we were in Q2 2020 versus where we were in 2019, we expect retail to be up, call it, 15% to 20% plus and so Tough comp to 2020, but continued industry growth if you look back to the 2019 timeframe.
Got it. Thank you.
And the next question will come from Greg Budishkanian with Wolfe Research. Please go ahead.
Hey, guys. Good morning. It's actually Fred Weipen on for Greg. Just wanted to dig into the expectations for the full year powersport market. I think you guys are expecting that to be down low single Digits now.
Last quarter, that was down high single digits. Could you sort of touch on what changed? How big is it more Stronger demand lasting longer, is it better ability to supply that that's driving the improved outlook?
Hey, Fred. Yes, I think it's just better demand. I think we had been anticipating that things would start to drop off earlier in the Q1 That we would see strong retail performance, but would be on a reducing basis, and that really wasn't the case. And March actually was incredibly strong month for us. So I think it's just overall industry strength.
I think I don't know if I want to correlate it to a delay in the reopening of the economies, because I have a firm belief that even after the economy is opened up, I don't think you are See a substantial change in the fact that people are going to want to continue to enjoy the outdoors and our products offer an incredible way to do that with their friends and family. But I think it's overall industry health. I think the economic backdrop certainly helps. I think the economy is far stronger than anybody was And I think it's going to continue to be stronger for the foreseeable future. So we're really encouraged by that.
And if we weren't, we wouldn't be making the capacity additions.
And just to shift
to that output side of the equation, last quarter you talked about absenteeism in the 20% range. You guys called that out in the slides again this Can you touch on what you're seeing from a rate perspective, if that's picked up, what the labor backdrop looks like and how that's sort of playing into some of the supply constraints?
Yes, I would say that the factory dynamics are less of our issue, and that's why we put that red line on Certainly, absenteeism rates are still higher than they have been historically. I think we're navigating that much better. I think With the vaccine rollout, we've had success at a number of our locations hosting clinics, where a substantial portion of the Manufacturing population is able to voluntarily get vaccinated and that certainly abates some of the concerns that we saw kind of late last year as employees were returning to the factory. The real issue for us isn't the plant, it's It's around the supply chain. And as I mentioned in my prepared remarks and a couple of the other questions, we're continuing to expertly navigate that and we feel confident we'll be able to
Demand. Perfect. Thanks guys.
Thank you.
And the next question will come from Scott Stember with C. L. King, please go ahead.
Good morning, guys, and thanks for taking my questions. Good morning. Good morning.
Can you maybe I'm not sure
if you touched on this already, but could you talk about the cadence of guidance for the year?
I know the back half of the year
We'll have some price increases coming through and some improvements on the supply chain side, but just for modeling purposes, how we should look at second quarter Versus the last two quarters of the year.
Yes. I think the way to think about this year, Which is different than sort of a normal year. We tend to see some seasonality in Q2, Q3 tend to be our bigger quarters. This year, just given the strength of retail in Q1, where we see it going for the year, I think there's a lot of customers, People are buying earlier into the season, so the normal timing is moving around a bit. I would think about the next three quarters all being very similar to Q1 from both revenue and profitability standpoint.
We're talking absolute terms or as far as Year over year or just percentages or absolute numbers?
Absolute numbers. Because what you see in the second half of the year, So most of the commodities cost, a lot of that's hitting us starting in Q2. We were already locked in on pricing in Q1. So that starts to hit in Q2, Moves around a little bit in the back half. Price increases come in, in May, and then obviously, we'll look at what that looks like for the rest But a lot of the promotions benefit was in the is in the first half of the year.
There's puts and takes, but I think they'll generally look fairly similar on an absolute basis.
Got it. The last question just on global adjacent markets. It's Quietly improving very nicely and I guess the powersports markets take all the glory. But can you maybe talk about Global Adjacent and what's driving that internationally?
Sure. So If you look at Global Adjacent Markets, our Exim business in Europe, which sells L6 registered vehicles to consumers in Europe, that's recovered really well and Had a strong Q1 and anticipating a strong year. Our GUPEL business in Europe also has picked up nicely coming out of COVID is performing well for the year. On the U. S.
Side, really the strength has been in our commercial utility vehicle market where we sell Ranger derivative products, mostly to the rental industry and that those industries are starting to recover as construction comes back and events Slowly claw their way back, so people had really taken down their inventory levels at the rental companies and so we're seeing some nice recovery there too.
Great. Thank you.
Thank you.
The next question will come from Joe Altobello with Raymond James, please go ahead.
Thanks. Hey, guys. Good morning. I just want to go back on price increases for a second. You mentioned ORVs up 2.5% starting May 1.
Is there any sense that competitors are doing the same since I would imagine they're seeing the same Cost pressures as you guys are.
Yes. I mean, we do monitor. I mean, given the fact that we share 60% to 70 The dealer network, we do get Intel, and we do know that there are price actions that have happened before us and after us. And I think each OEM is taking their own specific approach, but I do think it's The mix of MSRP changes as well as freight or logistics add ons.
Got it. Okay. And In terms of gross margin, obviously, a lot is going on right now. But how are you guys thinking about your longer term gross margin? Do you still see an opportunity to get back to that prior peak margin tariffs aside, obviously, exiting next year or does that get pushed off essentially?
Well, I think there's some complexity around it. And I hate having this discussion because it always feels like there's a but to the But there is. I think the one time costs that we're dealing with now and we do think they're one time. The elevated whether it's steel, resins, From a commodity standpoint, certainly the logistics spike that we've seen, we do think those are going to abate. And as I pointed out in my prepared remarks, Our supply chain transformation continues to progress incredibly well.
And so we're continuing that upward trajectory. These one time costs are going to start to abate. Obviously promo and some things like that will start to come back in. But we look at it as an opportunity for us to leverage the existing footprint we have. And I think The biggest unknown that we've got is where are tariffs headed, which is not something we spend an awful lot of time talking about.
And frankly, I think It's too early in the new administration's timeline for us to have a viewpoint. I mean, we obviously continue to self advocate and work through the whether they are political or through the administrative channels. But I don't suspect we are going to hear a whole lot until the end of the year or maybe into next year. And I think that's going to be one of the biggest unknowns for us to be able to get to that high 20% range. Bob, anything you would
Yes, sure. Ken and I, our teams are working really hard to track and work on plans to make sure that the One time costs that are coming in this year around expedites and logistics come out of the system as those challenges abate and that's a big chunk of it. Commodities, we expect to start to trend back more towards normal as we get kind of exiting 2021. I don't think it's going to anytime soon. But I think as we get back into the Q4, depending on what happens with the rest of the economy, that should start to settle down as some more Capacity comes back online.
Obviously, the storms in Dallas kind of piled on to a bad situation. And so some of that's starting to flow again and those costs are starting to mediate a little bit. And then really on the long term side, to Mike's point, it's really the focus on the Sunburst project and make sure we execute on that and drive the value out of that that we've targeted to do and what we can do to leverage The footprint. So I think you'll see us continue to march down that path. The timing is going to depend on the timing of some of these Thanks.
Got it. Great. Thanks guys.
Thanks Joe.
The next question will come from Garik Johnson with BMO Capital. Please go ahead.
Good morning. Thank you. You mentioned that mix was negative because of constraints More so than demand. So you're probably producing more ATVs probably through side by sides, would that be correct? And maybe you have a bigger backlog for side by side?
And then also kind of related to that on the demand side, what do you see the mix or anything towards at retail?
Thank you.
Sure. Yes. So you guessed correctly there on the ATVs versus side by sides. When you just look at an ATV from a Design standpoint, it's a simpler product. It has about half the parts of the side by side.
So just mathematically, your chance of Your supplier problems are going to impact it less just because you have less parts to be impacted. So we've been able to build ATVs at a higher rate than We have side by sides with some of the logistics challenges. From a demand standpoint, I think the demand is so strong right now that it's pretty solid across the board. Obviously, we're focused on trying to recover side by side build in the later part of the year, and we feel like we'll have some ability to do that. But that mix is still going to continue to impact us.
The other side of mix, which I really didn't get into, is the international And PG and A growing really strong, international also growing strong, but international margins tend to be a little bit lower. So those 2, To some degree, counter each other.
Okay. And what are you seeing in terms of financial characteristics of the end consumers, the credit quality there and What are your financial partners saying about delinquencies and things of that nature?
It's been pretty benign. I mean, financing has been readily available. We're not Seeing higher default rates right now. I mean, obviously, we're not in the financing business. We do that through partners.
But Consumers have found available financing at competitive rates, and we don't think financing is having a big impact on the industry right now.
Fantastic. Thank you, guys.
Thanks, Garrett.
The next question will come from Robin Farley with UBS. Please go ahead.
Great. Thanks. I wanted to just clarify first one of your comments about retail expectations for the year. Was that down low single digit your expectation for the industry or for yourself specifically or maybe it was both? And then also wanted to And see if you could help us quantify the restocking opportunity that sounds like in 2022, when you think about Whether it's in dollar amount or kind of shipment, if you could help us think about if sales were flat next Just that restocking piece of it though, would that be equal to kind of what percent of 2019 shipments or what percent of 2019 retail?
In other words, that just the inventory piece, if you could help us So think about that, what that has the opportunity to offset in 'twenty two? Thanks.
Yes. So from a retail I mean, obviously, we don't quote guide retail, but when we look at our models, we think we're going to be flattish for the year, And that obviously has ORB down a little bit, motorcycle is up. And that's predicated on What we are projecting right now and obviously we'll continue to update that as we go forward. As I mentioned, we do see dealer inventory improving through the end of the year, But we're still going to be short of what is ideal. Last quarter, we talked about the fact that we were probably 30 40% below optimal level and obviously given better demand, we're even further than that.
So it's a restocking opportunity into 'twenty two. I don't want to throw any numbers out Rodney McMullen:] It's been better in April than we were expecting, and obviously we want to see the critical months of May June and how they play out, because that's going to be really important in terms of how confident we are in the back half as whether or not they're Potentially a stronger retail or not.
Okay. Thank you. And then just lastly, I don't know if you gave, what was the change in ASP in Q1?
Thanks. I don't think we did because we've got so many different moving
The next question will come from Jamie Katz with Morningstar. Please go ahead.
Hi, good morning. Nice quarter. I hope we can dig a little bit more into the profitability of the boat business. Given the flexibility of the cost structure, I think the gross margin came in a bit ahead of what we had expected and ahead of 20 nineteen's Q1. So is that something that And sustain over the remainder of the year?
Or was there some part of mix or some other factor that maybe we should or is this different in the Q1?
No, I think the Q1 is relatively reflective of The strength we see in that business, one of the things we really liked about the business model when we bought Boat Holdings was that the majority of pontoons, which is relatively flexible from a volume standpoint and not particularly capital intensive. So that team has done a great job being able to ramp up Production in Q1. Q2 will be a little bit more challenging just because of shortages of foam across the whole marine industry, Foam for seating and foam for flotation, so you'll see some challenges in Q2 2 that will pick back up in Q3, Q4. But in terms of gross margins for the year, we expect to be able to continue to improve as that business We've got a lot of cost improvement initiatives in place, but obviously it has the same commodities and logistics challenges as the rest of the business.
But even with the delay in Foam, that's not leading to an increase in cancellation of orders or anything like that?
No, no. We've been able to ramp up, I think, as faster, faster than any other manufacturer in the marine industry and keep pace. And we've focused on Customer sold boats to make sure they're getting them before the start of the season. So I don't think we're losing customers, And I think we'll be able to continue to perform the rest of the year.
Excellent. And then on the autonomous vehicles, I You guys said there was going to be more detail later in the year, but is there a way for you to just size what that opportunity is for us, maybe who the end user might be And what the total addressable market might be? Thanks.
Sure. That's a challenging question. Obviously, autonomy and Our sort of rapidly changing segments of the economy as the technology continues to improve. Well, I can tell you, our partner Optimus Ride with the GEM vehicle, they've got 5 operating sites Where they're running vehicles with a safety driver, they have a pretty aggressive plan to grow that as We can deliver the actual full autonomous vehicles in 2023, but And their view is it's a very substantial market. We agree with that.
Putting real dollars and units to it is pretty tough because it's all going to depend on The timing and the pace of the rollout. So we see it as a good opportunity, but a little too early to size it.
Thank you.
The next question will come from David MacGregor with Longbow Research. Please go ahead.
Good morning, everyone. Kudos to the team for execution in just a really brutal environment. So job well done. I guess, I wanted to ask about market share gains here. And under more normal circumstances, the consumer is going to make their purchase decisions based on branding and product features and everything else.
I can see where in this environment, It might swing a little more towards availability. So I guess I wanted to ask you about your market share gains and do you feel that was just largely based on You just had better availability than your competitors or what do you think was behind that?
Yes. I think it's, David, it's tough I'll parse through it, but I would tell you that there's a couple of facts in there. I do think our availability, if you look at all the dealer Surveys or whether it's the ones that the sell side does or the ones that we do. Certainly, we have been better than many of our competitors, but I will tell you that they have Approved relative to where they were. So I don't want that to sound like there's just no competition in the channel because that isn't the case.
And I think if you walk into any dealership, you're going to see that front and center. So I think our demand is really being predicated on the fact that we've been very targeted around some of the promotional work that We do, and when I say promotional, it's about, you know, we're bringing, existing consumers back, recognizing loyalty to the brand. I think the innovation, I mean, we launched over 40 new products in the Q1 and that's just the start for the year. And the success we've seen with the snowmobiles, the success we saw with the new Trail Razor, In a lot of those instances, the products aren't even available, but the demand is through the roof in terms of orders. And the fact that we have customers pre ordering in terms of getting their hands on a vehicle as it's going through the factory.
I think speaks to it and I think that just Bodes well in terms of all the work we've done in terms of marketing and the innovation that we have around our products.
Sounds like it's sustainable. I guess the second question I wanted to ask you is just on RFM. You rolled this out a few years back The time when the market was actually in the flip condition and we had too much inventory at the dealer levels. And of course, now we're the other way around. At the time, the thought was that it would help you regulate The flow of product to the dealers, but how does it help you in this kind of environment now where the dealers are tight on inventory?
Do you just Run RFM wide open and it just lets product go wherever you can supply it or does it play some other governing manner here? I'm Trying to understand the role of RFM in the tight market?
Well, I think it's more complicated. But I think the basics are that we went through and did a lot of work around profiles. So as demand is heating up, obviously everybody is trying to get their hands on equipment and the profiles help us keep that in check So that dealers and their exuberance may be asking for more than what they really should have in a given region of the country. And so it helps us as we try and define that. It also helps us as we start lining up all the production.
And as I mentioned in my comments, the ability to get pre sold It's something that I think is really enabled because of the work we did around RFM. The flexibility we have in our manufacturing in terms of being able to model mix and make changes real time is not to be underestimated. And I think it gives us a real competitive opportunity. I mean, obviously, there was A little bit of a disadvantage when this all started because many of our competitors had bloated inventory levels and they were able to bleed those down, but that went away pretty quickly. And I would argue we're now in a better competitive position because we can react faster with our factories.
And when you couple that with The spectacular work being done by our supply chain to manage all the supply disruption, I think it creates a very strong winning equation.
Thank you. Thanks.
The next question will come from Joseph Spak with RBC. Please go ahead.
Thanks. Good morning. Good morning. I guess I wanted to just go back to Slide 8 and maybe some points of clarification. First, why does the unconstrained capacity go down in the Q4?
I would have thought that's just sort of like a theoretical Capacity. It says also you're adding capacity at select locations like how and I guess why are you doing that if you still have Ample capacity. And then finally, the gross cost savings $200,000,000 ahead of plan. Should we interpret that as It will come in sooner or the pie is potentially larger?
Yes. So a couple The reason the bars both dip in the back half, I mean that is from a production standpoint, it's pretty routine to take your factories down at the end of the year, required maintenance. You've got vacation time with the holidays, a number of those different things. Now I will tell you in the past, if you look at the end of 2020, we didn't ramp down as much because We've essentially paid to continue working through that time period, but I mean the factories are working at full capacity and you've got to do the right level of required maintenance. The reason, first of all, this graph does not have, for example, the boats manufacturing included.
This is really what I would call our core powersports ORB Motorcycles combined. The capacity add, so the boat capacity add obviously is not reflected here and that is helping because there There is some constraint there even though we are facing some of the same supplier issues. But we are adding because as we look forward, we anticipate the market is going to continue to grow and we've got new products coming online that we'll be able to add that additional volume in while not taking away from the capacity we need to produce the ongoing vehicles, and that's a big part of what we're doing down in Monterey. And as it relates to $200,000,000 I think we use the word slightly ahead. I don't want to get too excited because In the grand scheme of things, being ahead is good, but it's not enough to necessarily overcome all these other issues we have.
And we're going to continue pushing forward. And as Bob outlined, the good news is that these costs are going to continue to accrue. And once the one off costs that We're doing a really good job of tracking abate. We're going to be left with pretty substantial savings. It won't the $200,000,000 won't all be there by the end of this year, but We anticipate over the next several years, we're going to get ourselves there and probably ahead of schedule.
Okay. And then just maybe just on electrification, I know you have the 10 year exclusive with 0 on ORVs. Is there Scope to expand that to motorcycles, maybe not exclusive because I know they do their own bikes. And if not, can you just remind us of your Plans within the motorcycle segment?
Well, I mean, you saw some of it. I mean, we obviously targeted at the youth, but Yes. I would tell you, we learned a lot from the past when we had an electric motorcycle through the Victory brand. We do think it's an attractive segment and we're taking a hard look at it. And I would just say that as we look forward, we We continue to look for opportunities with our existing partner as well as any potential new partners, and we think it's a big opportunity.
Bob Obviously participated and led the process with Xero. So Bob, you want to add a couple of comments?
Sure. Obviously, The initial partnership is focused on off road, but we have regular conversations. There's opportunities to And we'll be expanding into the other product lines as we jointly feel it makes sense and motorcycles is an obvious one. It's also obviously the most challenging because 0's primary product is motorcycle, but we see opportunities with BoltZero or potentially other partners as we see That market is starting to grow in the future.
Thank you very much.
Thanks, Joe.
The next question will come from Mark Smith with Lake Street Capital. Please go ahead.
Hi, guys. I just wanted to look into PG and A just a little bit more. You talked previously about kind of the rebuy cycle and what you're seeing. Can you talk about kind of the Incremental buy within PG and A and any lag that you see from new customers, for instance, are they buying apparel A month or 6 months after or are we seeing more parts that are needed as new customers maybe or rough around some of these Then existing customers.
Yes. I would say that we probably don't have those stats, but when we look across the different Components of PG and A, as I mentioned in my prepared remarks, we're seeing growth pretty much everywhere. I mean parts are up over 30%, which I think is A good signal that folks are using their equipment, doing the repairs. We've done a lot with DIY videos so that folks, if they can't get into a dealership because the dealerships are pretty jammed right now, They can do the work themselves given their relative skill level. Accessories are up 60 That's a good indicator that folks are accessorizing their vehicles after they bought and we actually view that as a big opportunity as we're going through the sale process at the dealership.
We're a little challenged because of the backlogs that we're dealing with in our PG and A supply. But over the long term, we think that there is a big opportunity to continue to increase the amount of content That we have on the vehicles as they come off the showroom floor. And I think the fact that our accessories are up 60% is just an indicator that consumers do look for Ways to make the vehicle unique for themselves. So, the growth is great. It's obviously highly profitable for us, And we're seeing it pretty much across every element of PG and A.
Great. Thank you.
The next question will come from Billy Kovanis with Morgan Stanley. Please go ahead.
Hi, guys. Congrats on a great quarter. Just wanted Summarize a lot of the commentary on this call and tell me if I'm right here, but your inventory levels are currently down 71% And you are going to build some inventory through the rest of the year. Even if we assume sort of 2022 retail sales are down, doesn't this give you a pretty good sort of production Runway up until mid to late 2022. Can you just correct me if I'm wrong there?
The first question?
Yes. I think the only thing I'll correct you on Is using the word late 2022 because I don't know that we have that clarity yet. I was we were very deliberate around our word sometime in 2022. And I think that's important and we're going to continue to watch because it really does depend on how things cadence out. And I mentioned it I think when I was responding to Robin's question.
April is important, but May June are just as important. I mean we saw Tremendous growth that led to the 57% year over year increase in the Q2 last year and really understanding how that's Understanding how that's patterning out, I mean right now, if April is in any indicator, it's stronger than we expected, and so that's obviously going to influence How we characterize the 2022 timing of the channel refill.
Awesome. And then just Shifting to electric real quick. Any customer feedback that you can share with us in your initial model releases? And is there any plan to potentially Bolt on, any company that you think would give you some edge in electric manufacturing? Thanks guys.
Yeah, I mean we really we don't have anything out in the market per We have our existing products out there. What I can tell you is if you haven't seen the video that we put out on the new electric Ranger, We're demonstrating its capability here in our very cold Minnesota backdrop. And I can tell you, I mean, it's just a phenomenal vehicle and the Teams continuing to refine it. And the best part about our strategy, we're working with 0 who's got the powertrain expertise and understands the components and how to configure. And we're dedicating our time and energy to what we do best, which is really around the design of the vehicle and the chassis.
And when you marry those 2 together, I think it's going to be an incredibly Powerful combination and I think that's what you see coming out with the teaser videos that we have on the Ranger. So we'll know as we get into 2022 when we launch that vehicle, but I fully expect it's going to be an incredible reception.
Thank you.
Our next question will come from Sean Collins with Citi. Please go ahead.
Great. Hey guys, good morning.
Good morning, Sean.
Hey, Suwad. I wanted to ask about the motorcycle industry. Huge retail quarter at Indian, up low 60s. Your U. S.
Peer had retail up 30%. It's certainly nice to see the industry grow following Huge growth in off road, RVs and boating. Can you possibly provide some qualitative color on kind of what you're seeing and hearing from consumers? And And if you think the motorcycle industry and Indiana is set up for a better industry tailwind for the rest of 'twenty one. And Mike, I think you had said that you
Yes. I mean, look, I think the backdrop is that the industry is Poised to do better. I think we've talked a number of different times that the industry given the dominant player is really predicated on how they did last year, Wasn't great. So the industry is doing better partly because of that, but because we're outperforming. I mean our market share gains continue.
We introduced the new Chief, which essentially kind of fills out the Indian platform. And I will tell you, I mean, we are seeing strength across the board, Whether it's FTR, the Bobber, the demand for the new Chief, as well as our heavyweight bikes. And I think it's just the unique As of the brand, the bikes are beautiful. They're engineered incredibly well, and we think we're going to continue to win that competitive battle for the foreseeable future.
Great. That's helpful. Thank you very much.
Okay. That's the last question. Just one follow-up on the ASP. Off road vehicles ASP was up approximately 6%. Motorcycles ASP was down about 2%.
That was really the mix between the full size motorcycles and the midsized motorcycles. And then for the total company, it was up about 4% on ASP. With that, we'll end the call. I want to thank everyone for participating. We look forward to talking to you next quarter.
Goodbye.
The conference has now concluded. Thank you for attending today's presentation. You may now disconnect.